I had just taken my waverunner out, and after having to start it up a few times the battery will die on me..the battery we new this summer..wondering what could be the problem
Announcement
Collapse
No announcement yet.
Battery issues
Collapse
X
-
Re: Battery issues
First of all how long have you owned this PWC? then have you checked the water leve in the battery? Check the connections to make sure they are not loose or corrded. Check the ground on the starter to make sure it has good connection. The other check is using a multimeter and jumper cables. Try hooking the pos leads on the cable to the battery pos and pos cable. Start the engine and remove the jumper from the battery if it dies then you need a new magneto assembly located in the front of the engine which usually requires you to remove the engine. If it does not die then check with multimeter to see if the charge is 12-14vdc or what ever your repair manual says it should be. Most likely unless you have had to change out the starter or hear something knocking around in the fly wheel cover area, most likely it is a bad connection in the electrical area or def battery.
Comment
-
Re: Battery issues
Originally posted by gunbunny316First of all how long have you owned this PWC? then have you checked the water leve in the battery? Check the connections to make sure they are not loose or corrded. Check the ground on the starter to make sure it has good connection. The other check is using a multimeter and jumper cables. Try hooking the pos leads on the cable to the battery pos and pos cable. Start the engine and remove the jumper from the battery if it dies then you need a new magneto assembly located in the front of the engine which usually requires you to remove the engine. If it does not die then check with multimeter to see if the charge is 12-14vdc or what ever your repair manual says it should be. Most likely unless you have had to change out the starter or hear something knocking around in the fly wheel cover area, most likely it is a bad connection in the electrical area or def battery.
Comment
-
Re: Battery issues
okay just checked all connections..they're all good but when i checked the fuse going to the rectifier looked fine but i found little orange droplets inside of that fuse..should i replace that fuse and could that be the problem?
Comment
-
Re: Battery issues
was the droplets hard or wet, could be a little corrosion or it could be due to current almost causing it to blow. use an ohm meter to check it. I would suggest replacing it. The cost is only 20cents :emoticonc but thats not it I sugest try unconnect some of the conectors and reseating them, might have a bad connect and thats all it needs. Intermittant problems are always hard to find. Connectors are tricky even though you can snap them in If the male and female pins do not touch just right a cold or hot enviroment can cause them to loose contact. Also make sure they have a dialectric grease in them to prevent water from entering and keeps them sealed and dirt free.
Comment
Comment