Announcement

Collapse
No announcement yet.

1998 ts 770 tigershark, geting to much feul

Collapse
X
 
  • Filter
  • Time
  • Show
Clear All
new posts

  • 1998 ts 770 tigershark, geting to much feul

    i have a 1998 tigershark 770 and it seems to be geting to much fuel,

    SYMPTONS: starts fine,idles fine,runs good up to 1/8 throttle then from there to full throttle it seems like its geting held back and wont go any faster or clear out. its not a bog just seems like its flooding out, if i turn fuel to off it rips good for a few seconds till it needs fuel again then i turn it back on and it back to the same problem,

    THINGS IVE DONE SO FAR.
    took off carbs and cleaned/inspected them
    set to stock settings
    hose clamped and checked all fuel lines
    changed spark plugs
    drained fuel and put fresh fuel in

    and the first time i took it out after doin all this i forgot the fuel restricter (looks like a little brass jet) that goes in the fuel line from the accelerator pump to the carb on the pto side carb and it ran worse in lower rpms but got up to higher rpms and higher speeds without the resticter (brass jet thing that goes in fuel line from pump to carb)
    now that i put it back in it runs great at idle to 1/8 throttle but then just seems like its flooding out and cant burn fuel off till i turn gas off then it rips for a few seconds then it burns off all the fule then i need to turn gas back on then it goes back to the same thing.
    thanks for any help and advise.
    if some one can find a fuel line routing diagram that would be much appreciated also.
    Last edited by Yamahafan#1; 06-02-2017, 01:16 AM.

  • #2
    Re: 1998 ts 770 tigershark, geting to much feul

    hello??? any one home???

    Comment


    • #3
      Re: 1998 ts 770 tigershark, geting to much feul

      You can take a look at the parts diagrams here[CountryCat.com], maybe that will help.
      The service manual I have is for a 1997 and it does not show a diagram.
      CountryCat.com
      Last edited by SBT-Tech 1; 06-06-2017, 08:47 AM.

      Comment


      • #4
        Re: 1998 ts 770 tigershark, geting to much feul

        thanks for the reply

        Comment


        • #5
          Re: 1998 ts 770 tigershark, geting to much feul

          Still cant figure out why im having this problem guys.

          Comment


          • #6
            Re: 1998 ts 770 tigershark, geting to much feul

            It sounds like your needle and seat are leaking.
            When you set everything to stock settings, what was the pop off pressure?

            Comment


            • #7
              Re: 1998 ts 770 tigershark, geting to much feul

              i didnt set it because i was told that it only effects idle to 8th throttle. and it runs great in that throttle range

              Comment


              • #8
                Re: 1998 ts 770 tigershark, geting to much feul

                Is this true

                Comment

                Working...
                X